纯棉针织物的秦皮天然染料染色

以水为提取剂从中药秦皮中提取天然染料对纯棉针织物进行染色,研究不同媒染方式以及染料质量浓度、染浴pH值、染色温度及时间、媒染剂硫酸亚铁用量等后媒法染色工艺对纯棉针织物染色效果的影响.结果表明,后媒法染色效果最好,秦皮天然染料对纯棉针织物的后媒染染色最佳工艺为：秦皮天然染料质量浓度12g/L,染液pH 4,染色温度90℃,染色时间60min,媒染剂硫酸亚铁用量5g/L.织物经后媒染染色后得色均匀,各项色牢度较好.     

糜蛋白酶预处理羊毛的低温染色性能

用正交试验法研究了糜蛋白酶对羊毛纤维的预处理情况,再用染料酸性大红BS在较低温度下对预处理后的羊毛进行染色,测定了羊毛的上染率、表观色深值、断裂强力等性能。实验结果表明：在糜蛋白酶用量为2％（owf）、pH值为7、温度为40℃、时间为60min的预处理条件下,酸性大红BS在80℃下染羊毛的上染率达到95．1％,色深值（K／S）达到15．05,强力下降率只有5．78％,与常规染色工艺条件下的染色性能相比,上染率和色深值均有提高,而纤维强力损失较小。     

低温等离子体处理对羊毛织物性能的影响

采用空气低温等离子体对羊毛表面进行改性处理,探讨了等离子体处理对羊毛织物抗毡缩性、强力、白度、润湿性、染色性能等的影响.正交试验结果表明:等离子体处理羊毛织物的实验室最佳工艺为时间3min、压强50Pa、功率150W.经空气低温等离子体处理,羊毛织物的毡缩率和白度降低,而润湿性、强力和弱酸性普拉红B染色K/S值提高.单独经过空气等离子体处理的羊毛织物达不到"机可洗"的要求.     

消除精纺丝毛混纺织物─浴匹染色差的研究

精纺丝毛织物匹染时，由于羊毛绢丝纤维的结构有差异，易产生色差．本文重点探讨了消除丝毛混纺织物─浴匹染色差的工艺条件．     

Enzymatic Treatment of Wool

Three proteases were applied to treatments of wool. The shrinkage, dyeing behavior, some physical and mechanical properties of treated wool were studied. Peroxymonosulfate(PMS) and lipase were used to pretreat wool before the treatment of it by protease. The results show that the shrink resistance of wool fabric is not obtained when it is treated only by the protease, but it is remarkably improved when the wool fabric is treated first by PMS or a lipase afterwards by protease. The rate of dyeing is increased when the wool is treated by protease or combination of oxidant/ lipase and protease. Whiteness, luster and softness of treated wool are improved, while the strength and elasticity are reduced.     

温度和pH值对羊毛织物尺寸稳定性的影响

通过一系列实验分析了温度和pH值对羊毛纤维的膨胀和羊毛织物尺寸变化的影响．在pH2．1的溶液中，羊毛织物的尺寸随温度的升高而下降，变化的幅度取决于织物组织和织物的定型率．在羊毛等电点pH4．8时，纤维的膨胀达到最小值，而织物的尺寸则随着溶液酸性的增加而减小．     

Mathematical Model for Application of Simulated Tikuanyin Tea Residues on Wool Dyeing Process

The central composition experimental design of multiva-riate Response Surface Method was used to formulate mathematical models aiming to predict (1) the optimum dyeing conditions of simulated waste Tikuanyin tea for wool fabric and (2) the optimum extraction conditions of a natural mordant originated from common waste eggshell. The pre - mordanting eggshell was applied to wool fabric before dyeing with simulated waste Tikuanyin tea under the optimum dyeing conditions. After mordanting the wool fabric with extracted natural eggshell solution, the prominent effect of increment in dye uptake and improvement of the properties of light fastness, washing fastness and rubbing fastness were evaluated.     

羊毛纬平针织物抗起毛起球整理与性能

选用一种低温环保型水性丙烯酸酯共聚乳液,对羊毛纬平针织物进行了抗起毛起球的整理,研究了整理剂质量浓度、浴比、时间、温度4个因子对羊毛纬平针织物整理效果的影响.根据正交实验得出较优工艺参数为:整理剂质量浓度30g/L、浴比1:35、温度50℃、时间30min.经该工艺整理后可提高羊毛纬平针织物的抗起毛起球性能和织物强力.     

One-bath Dyeing of Polyester/Wool Blend with Disperse Dyes

The role of auxiliary LAB as vehicle in dyeing polyester/ wool blends with disperse dyes is described. Dye exhaustion and bonding on polyester/wool samples are studied under different experimental conditions - the LAB amount, the temperature and pH value - to achieve optimum conditions. The results are compared with those obtained with and without conventional dyeing auxiliary products. Although dye exhaustion is higher in the presence of commercial carriers, the dye bonded increases markedly in the presence of auxiliary LAB in both fibers. The role played by auxiliary LAB in polyester/wool blend dyeing can provide a new method for this process.     

Enzymatic Treatment for Shrink-proofing of Wool

Introduction Duetothescalestructureandresiliencyproperties, woolhasatendencytoshrinkundertheinfluencesof moisture,detergentsandagitation.Nowadaysthemost commerciallysuccessfulshrink proofingprocedureistheIWS/CSIROchlorine Hercosetttopprocessasa combinationofsubtractiveandadditivemethods[1,2]. However,apartfromyellowingandresultingasynthetichandle,thisprocessproducesabsorbableorganichalogen compounds(AOX)[1,3],whichcauseseverepressureon environmentallegislation[4,5].Forecologicaland econ…     

Ultrasonic assisted dyeing：Dyeing of wool fabrics as Dioscorea Cirrhosa Lour. a natural dye

The use of Dioscorea cirrhosa Lour.in the dyeing of leather and silk have been some 2000 years in China as the natural coloration.Power ultrasound has been explored in the textile coloration.This article aimed at researching the ultrasonic efficiency for dyeing wool fabric with Dioscorea cirrhosa Lour.dye in comparison with conventional heating.We get a significant improvement in the color strength values(K/S) at the same condition.The fastness and extent properties of the fabrics treated by ultrasonic were better than those obtained when treated by conventional heating.     

The Application of Microwave Low Temperature Plasma in Pretreatment of Cotton Fabric

The effect of microwave low temperature plasma pretreatment on desizing and removing natural impurity of cellulose fiber was studied. The influencing factors of pretreatment such as treating power, gas pressures and time were discussed in detail and the final effect had been compared with that of traditional pretreating process of cotton fabric. The results showed that better capillary effect, strength, whiteness and dyeing K/S value could be given by means of microwave low temperature plasma treatment.     

Research on the Dyeing and Finishing Properties of Wool Treated with Chitosan

The dyeing and finishing properties of wool treated with chitosan were studied. It was shown that chitosan can be absorbed by wool in an acetic acid bath, both dyeing rate and equilibrium dye uptake of wool treated with chitosan increase in a wide pH range from strong acid to neutral conditions. This work also indicated that chitosan could be used to achieve feltproofing of wool.     

电晕处理对毛织物表面性能的影响

对羊毛织物的表面进行了电晕处理，用XPS和SEM研究了处理前后纤维袁面化学结构及物理结构的变化，探讨羊毛的润湿性、表面静电性能和对植物染料染色性能的变化．结果表明，经电晕处理后，羊毛表面舍氧量增多，表面漫润性得到改善，增加了纤维表面的亲水性；此外，电晕处理导致鳞片表层胱氨酸的部分二硫键氧化断裂，改善了对植物染料黄连的染色性能，表现为上染速度提高，但上染率变化不大．     

Study on the Dyeing Behaviors of Low Temperature Glow Discharge Treated Wool

Wool tops was modified by low temperature glow discharge (LTGD). The inputted power, the treating time and the pressure or vacuum were found to play an important role. The wool tops were dyed with reactive dye under a constant dyeing temperature after plasma treatment. Then the dyeing behaviors were studied based on the data of uptake, fixation, dyeing rate and fixing rate. The results revealed the possibility of low temperature dyeing and the suitable parameter of LTGD treatment.     

稀土在毛制品上的应用

近年来，稀土元素作为纺织梁整助剂在羊毛纤维、纱线和织物的应用取得了很大进展，其中包括羊毛散纤维、全毛绒线、毛织物及全毛地毯等的染色和漂白，目前的稀土羊毛漂染是在不改变生产工艺流程，不增加加工设备条件下，将稀土作为一种漂染助剂加入染浴或漂浴中，起到染色增深增浓、缓染匀染，七约染化料，低温、低铬染色，提高颜色鲜艳度以及促进漂白等作用。本文阐述了稀土羊毛漂染的机理，总结了近年来的生产实践经验，以期进一步推动稀土在纺织染整领域中的应用和研究工作。     

低温等离子体技术在棉织物染整加工中的应用进展

低温等离子体技术作为一种清洁、高效、无污染的加工技术在纺织染整加工中越来越受到关注.本文通过调研国内外染整技术前沿动态,系统阐述了低温等离子体技术在棉织物染整加工各个主要环节(前处理、染色、印花、后整理)中的应用进展,并指出低温等离子体技术在棉织物染整加工中的未来发展趋势.     

超临界CO2染色技术研究

研究了纤维织物超临界CO2状态下用分散染料染色的操作方法和工艺技术,对超临界状态下溶解度、染色牢度、匀染性、织物强力、染色机理进行分析探讨,确定了影响染色效果的主要因素.经实验验证超临界CO2是可行的,对于我国纺织染整行业从源头上节约水资源和清洁化生产具有重要意义、     

超声波对超细羊毛纤维中性染料染色的影响

采用超声波处理对超细羊毛纤维进行不同深度的染色其影响不尽相同。研究表明,对于染料用量3 %(owf)以下的中浅色,染色前对纤维进行超声波处理,75 ℃染色可达到常规沸染的效果;而对于染料用量5 %(owf)的深色,超声波处理对染色有一定帮助,但作用与中浅色相比相差较多;超声波处理可以将染色温度降为85 ℃,减少纤维损伤,节约能源。     

Shrinkage Properties of Wool and Acrylic/Wool Plain Knitted Fabrics Treated with DC109

This paper examines the effects of shrink - resist treatment, washing cycle and fabric tightness on the shrinkage properties of plain knitted fabrics made from 100% wool, acrylic/wool (50/50) and acrylic/wool (70/30). It was found that shrinkages of both treated and untreated wool fabrics were negatively correlated to fabric tightness and exceeded the IWS shrinkage limits (5% in length and 8 % in area) after 2 - 5A washing cycle. The effect of tightness was not as obvious with acrylic/wool (A/W) fabrics, but the shrinkage was seen to increase with stages of washing cycle for untreated A/W fabrics with some exceeding IWS standard. By applying the DC 109 shrink - resist solvent treatment, it was identified that by with higher percentage of acrylic fibre blended with wool, shrinkage could be reduced considerably and within acceptable limits.