Microstructure,mechanical properties and wear resistance of an Al–Mg–Si alloy produced by equal channel angular pressing

Microstructure, mechanical properties and wear resistance in an ultrafine-grained Al–Mg–Si alloy fabricated utilizing a combination of equal channel angular pressing (ECAP) and dynamic aging were investigated in this paper. The results indicated that the grain size of the ECAP alloy was significantly refined, i.e., to ~239 nm after three ECAP passes. Meanwhile, the yield and tensile strength of the ECAPed material reached 340 MPa and 445 MPa, respectively, while maintaining a significant uniform elongation of 14%. Wear resistance results demonstrated that the wear rate, wear depth and width of the ECAPed material decreased in comparison with the solution-treated (SST) and peak-aged (T6) conditions under a load range of 5–25 N. The adhesive wear that occurs in the undeformed specimens at 10 N does not appear in the ECAPed specimen at the same load, indicating that the ECAPed specimen delay the appearance of more serious wear mechanisms under certain loads. The cooperative interaction of high density nano-scale β" precipitates and dislocations resulted in a combination of super-high strength and good work hardening ability which suppressed the extension of cracks between the friction layer and the plastic deformation zone. As a consequence, the combination of ECAP and dynamic aging brings a significant improvement for antifriction performance of the 6061 aluminum alloy.     

光引发丙烯酰胺沉淀聚合研究

以丙酮/水为溶剂，采用紫外光（UV）引发丙烯酰胺（AM）沉淀聚合，考察了聚合反应的特征以及溶剂、初始单体浓度、引发剂浓度、表面入射光强、液层厚度等参数对聚合物分子量的影响。结果表明，紫外光引发丙烯酰胺沉淀聚合过程中单体转化率和聚合物分子量都随反应时间的延长而增加，光照80min时，单体转化率可达90％以上。所得聚合物分子量为10⁵～10⁶，提高单体浓度可使聚合物分子量增加，增加引发剂浓度和提高光强导致聚合物分子量降低，液层厚度对聚合物的分子量影响不大。所得聚合物粒子粒径约为200～300nm左右，粒径分布较为均匀，溶剂组成对聚合物粒子相貌影响较大，增加水含量可使粒子粒经变大但分散性变差。     

纳米氧化锌粉的表面改性研究

以Zn(NO3)2·6H2O和CO(NH2)2为原料,采用均相沉淀法制备纳米氧化锌粉.用扫描电镜对产物粒度大小、形貌进行观察,并对其影响因素进行了探讨.结果表明,在反应温度为120℃,反应时间为2.5h时,所制的纳米氧化锌的产率最大.用不同的表面改性剂对纳米ZnO进行表面改性,粉体不再发生团聚.图6,表7,参5.     

老龄产业发展战略的思考

论述新世纪发展老龄产业的意义、作用、制约因素和内容．目的在于通过老龄产业的发展来解决日趋严重的人口老龄化问题；并运用实证分析法阐明经济发展、计划生育、社会安定与人类进步的关系。     

硅、铋离子鉴定方法的探讨

本文对现用叙材中硅、铋离子的鉴定方法进行了改进,改进后的鉴定方法既简单快速,又灵敏可靠.     

线粒体与人类疾病

线粒体自身携带DNA，可自我复制、表达。研究表明，线粒体DNA突变的积累和氧化损伤与人类疾病、衰老和肿瘤密切相关。     

泡沫分离,带溶剂萃取和沉淀法提取庆大霉素

研究了用文题法从水相中分离砂大霉素的各种操作因素对分离过程的影响。在最适条件下，种方法对庆大霉素配制液的收率分别为７２％，８８％，８７％，无机盐能使沉淀收率提高。将上述３法用于发酵液时，泡沫法和萃取法的收率均有显著降低，而沉淀法依然能达到很高的收率，ψ＝捍沉淀率约为１００％．     

金属工件内部残余应力的振动消除研究

本文针对传统的消除金属工作内部残余应力的热时效处理法的不足，从激振角度，运用材料力学、动力学中的振动理论等知识，并通过大量试验验证，研究了振动消除应力的方法－－振动时效法的原理及其有关问题。说明这种新的方法具有节能、高效等一系列优点。     

Age distribution of circulatingα-interferon

Summary A sensitive radioimmunoassay showed that circulating -interferon in the plasma of healthy individuals was low in children and reached the highest level in the young adult, then declined gradually with age. Circulating -interferon was 0.201±0.059 ng/ml in males (n=19) and 0.184±0.076 ng/ml in females (n=14) at ages 30–39 years old. It was noted that circulating -interferon was maintained up to a certain level even in elderly individuals.     

Wine technology: Current trends

Conclusion Current enological research does not aim at developing technological wines whose organoleptic characteristics are basically determined by the methods used in the transformation of grape wine, but rather to refine methods which will highlight the original qualities of different cultivars and viticultural conditions.