羊毛低温染色的研究

本文采用乙醇胺予处理(简称MEA)及染浴助剂相结合的方法,对媒介染料羊毛染色进行了探讨。文中分析了MEA予处理羊毛对染色的影响;讨论了低温促染剂GF在媒介染料染色中的作用机理;确定了在85℃条件下进行低湿染色的工艺。该工艺与常规染色相比,提高了上染率,减少了纤维损伤,同时改善了纤维性能,提高了折皱回复角。     

生物蛋白改性助剂对羊毛纤维的改性研究

研究了NaHSO3预处理条件,以及鸡毛蛋白改性助剂改性条件对羊毛纤维活性染料和酸性染料染色性能的影响.结果表明,经过NaHSO3预处理与鸡毛蛋白改性助剂联合改性的羊毛纤维可以显著改善染色性能,提高染料上染百分率、固色率、耐洗色牢度,尤其适合染深浓色产品.同时,毛织物吸湿性提高,穿着舒适性改善.     

保护剂WSE在丝光羊毛漂白中的应用

WSE对羊毛纤维具有溶胀和交联作用,将羊毛保护剂WSE应用于丝光羊毛的漂白,优化了WSE的应用工艺.通过对漂白羊毛单纤维的断裂强力和散纤维的白度测试,表明保护剂WSE可以显著降低羊毛纤维在漂白中的损伤,并提高羊毛纤维的白度.     

稀土在羊毛染色中作用机理的研究

本文在稀土助染工艺应用研究的基础上,采用多种化学及物理方法,比较全面地研究了羊毛染色过程中稀土离子的作用,较好地从化学的角度说明了稀土染色中节约染料、节约红矾和改善染色织物手感的原因。     

阳离子丝素助剂改性羊毛及改性纤维染色性能

用自制的阳离子改性丝素助剂整理羊毛纤维，研究整理工艺条件对羊毛纤维染色性能的影响．结果表明，改性的丝素助剂整理的羊毛纤维显著改善了对活性染料的染色性能，同时整理的羊毛织物防缩抗鹱性能提高．     

梁料化学结构对稀土染色效果的影响

稀土是否可以作为染色助剂，已经引起广泛关注，实验发现，稀土染色效果与染料种类有直接关系；并可将染料分为三类：一类为稀土染色在样品颜色外观上有明显增浓现象，可节省染料量5－15％；另一类为稀土染色在样品颜色外观上虽无明显增浓现象，但透染性能良好。经三类为稀土染色有明显的色相改变现象，对进一步研究稀土染色机理和指导生产应用有一定意义。     

全毛针织绒线绞纱防毡缩及其染色工艺

论述了全毛针织绒线绞纱氯化一树脂防缩法．用二氯异氰脲酸盐作为释氯剂，阳离子自交联非硅聚合物为树脂，通过释氯剂的不同用量及处理浴的ｐＨ值和温度变化，研究全毛针织绒线的处理效果．得出采用３％释氯剂滴加（处理浴ｐＨ值为４．５、温度为３０℃）和３％树脂进行绞纱防缩处理，防缩效果达到了国际羊毛局机可洗的标准．选用适当的染料（兰纳素和兰纳洒脱染料），试验释氯剂对色变的影响；对不同的颜色，根据释氯剂对其影响程度的大小，采用不同的处理顺序（先氯化处理后染色或先染色后氯化处理）．对先氯化处理的全毛针织绒线染色性能的研究结果表明，适当地提高染浴的ｐＨ值，降低染浴的始染温度，必要附加入适当的释酸剂控制染浴的ｐＨ值，有利于染色的均匀．防缩后的全毛针织绒线的色牢度符合国际羊毛局机可洗的色牢度要求．     

丝光羊毛Lanasol微悬浮体染色研究

采用Lanasol系列染料以微悬浮体染色工艺对丝光羊毛进行染色.比较了微悬浮体染色和常规染色工艺Lanasol 染料对丝光羊毛纤维的染色性能以及染品的损伤程度.结果表明,采用微悬浮体染色工艺,在保证匀染和透染的前提下,能显著缩短丝光羊毛的染色时间,减少纤维在染色过程中所受的损伤,节约能源,而且染色样品色泽鲜艳,色牢度均与常规染色样品相当.     

含萘环通用染料的合成与应用研究

为了实现用同一支染料对不同类型的纤维进行染色的目的,通过间(对)氨基苯基-β-羟乙基砜硫酸酯与7-乙晚氨基-4-羟基-2-萘-β-(N,N-二甲基氨乙基)磺酰胺的重氮化偶合反应合成了含萘环的通用染料,其结构通过质谱分析进行了表征.通过调节染浴的pH和加入适当的染色助剂,用合成的通用染料分别对棉、羊毛、丝绸、尼龙、腈纶、涤纶等纤维进行了染色实验,并研究了染料在上述纤维上的日晒、水洗等牢度性能.实验结果表明合成的含萘环通用染料对羊毛、丝绸、尼龙、腈纶等纤维均有较好的亲和力.     

羊毛的变性及变性羊毛阳离子染料染色

羊毛经阴离子型活性变性剂处理后，纤维侧基上被引入阴离子型基因，具有和腈纶纤维类似的结构。因而，变性羊毛能够用阳离子染料染色。增大变性剂的分子量、共轭双键数及相对疏水性，变性羊毛用阳离子染料染色时上染速率和上染率均可显著地增大，染色牢度也大为改善，但对酸性染料产生防染作用。从变性羊毛的红外吸收光谱图上可看到，在波数为１１５０～１２６０ｃｍ－１、１０１０～１０８０ｃｍ－１和６００—７００ｃｍ－１处均出现磺酸基的特征吸收峰。变性剂和羊毛间形成共价结合成为纤维侧基的一部分。变性羊毛表面的电性能有较大变化，但其物理机械性能如减溶解度、弹性、断裂强度等基本不受影响。     

乌拉圭羊毛理化性能及其可纺性的研究

着重研究乌拉圭细羊毛和半细羊毛在化学组成、形态结构、纺纱工艺性能和染色性能等方面的特点，并与相当细度的美利奴羊毛有关性能相对比．分析了ＭＩＣ２２．６、ＭＩＣ２６．８、ＭＩＣ２８．８三种毛条的纤维长度和细度分布特性，制定出可纺纱支的纱线规格和相应的加工工艺路线．结果表明，乌拉圭羊毛表面鳞片密度低并紧贴毛干，使羊毛明亮光泽；乌拉圭羊毛强力大，初始模量高，卷曲弹性率较低，表面光滑，摩擦系数小；乌拉圭羊毛含有较少的自由氨基，上染比较缓慢．根据其特性，作者认为乌拉圭羊毛加工过程中需特别注意和毛油剂种类的选择，同时宜采用较低的单纱和股线捻系数，设计色泽鲜艳、要求保形性能好的产品．     

染料化学结构对稀土染色效果的影响

稀土是否可以作为染色助剂,已经引起广泛关注。实验发现,稀土染色效果与染料种类有直接关系;并可将染料分为三类;一类为稀土染色在样品颜色外观上有明显增浓现象,可节省染料量5～15％;另一类为稀土染色在样品颜色外观上虽无明显增浓现象,但透染性能良好,第三类为稀土染色有明显的色相改变现象。对进一步研究稀土染色机理和指导生产应用有一定意义。     

Union Dyeing Behavior on the Blends of Tencel and Shrink-proofing Wool with the Same Reactive Dyestuffs in One Bath

In order to obtain union colour on the blends of Tencel and shrink-proofing wool and improve the efficiency of dyeing process, the dyeing behavior on the blends of Tencel and shrink-proofing wool in the same bath was studied. The Argazol TW reactive dyestuffs were involved in the dyeing process. The parameters under different conditions such as exhaustion, fixation, compatibility as well as soaping fastness were investigated in detail. It is shown that the Argazol TW reactive dyestuffs are suitable for dyeing of blends of Tencel and shrink-proofing wool and good dyeing behavior can be expected.     

Research on the Dyeing and Finishing Properties of Wool Treated with Chitosan

The dyeing and finishing properties of wool treated with chitosan were studied. It was shown that chitosan can be absorbed by wool in an acetic acid bath, both dyeing rate and equilibrium dye uptake of wool treated with chitosan increase in a wide pH range from strong acid to neutral conditions. This work also indicated that chitosan could be used to achieve feltproofing of wool.     

超声波处理对羊毛纤维性能的影响

以未处理、55℃超声波处理和沸水处理的羊毛纤维为研究对象,对比分析两种处理方法对纤维力学性能、表面形态、化学结构的影响,从纤维角度探讨超声波低温染色的机理.试验结果表明,经超声波处理后的羊毛,束纤维强度降低,油脂质量分数减少,纤维表面鳞片张角增大并产生不规则裂纹,部分二硫键断裂,纤维分子有序程度降低,因此,羊毛在染色过程中更易润湿,染料更易进入纤维内部并扩散.     

Low Temperature Dyeing and Shrinkage-Resistance Finishing of Wool by Composition of Salt-Ammonia and Enzyme Treatment

Wool top and knitted fabric were treated with ammonia in the presence of sodium chloride （salt-ammonia process）. The effectiveness of salt-ammonia process traditionally used as pretreatment for low temperature dyeing has been investigated for conferring shrink-resistance of wool. The pretreatmont of salt-ammonia process followed by enzymatic treatment has been proved that contribute to not only the enhancement of dyeing behavionr but also shrinkage-resistance in the present studies. A novel composition of salt-ammonia pretreatment, oxidized and reduced treatment as well as protease modification was recommended to achieve low temperature dyeing and shrinkage-resistance of wool. At the same time, the process conditions were optimized by orthogonal array and assessed by dye uptake rate, weight loss and area shrinkage. Laboratory experiments showed that the knitted fabric treated according to optimized conditions of the combined process, achieved not only improvement of dye abilities but also the strict requirement of machine-washable, representing a possible alternative to chlorination.     

One-bath Dyeing of Polyester/Wool Blend with Disperse Dyes

The role of auxiliary LAB as vehicle in dyeing polyester/ wool blends with disperse dyes is described. Dye exhaustion and bonding on polyester/wool samples are studied under different experimental conditions - the LAB amount, the temperature and pH value - to achieve optimum conditions. The results are compared with those obtained with and without conventional dyeing auxiliary products. Although dye exhaustion is higher in the presence of commercial carriers, the dye bonded increases markedly in the presence of auxiliary LAB in both fibers. The role played by auxiliary LAB in polyester/wool blend dyeing can provide a new method for this process.     

Sorption Behaviour of Acid Dyes by Soybean Protein/Poly （vinyl alcohol） Blend Fibre

The sorption behaviour of acid dyes by soybean protein/poly（vinyl alcohol） blend fibre was studied. The quantity of dye sorbed by the fibre increased markedly with the decrease in the pH of dyebath and reduced with the addition of neutral electrolyte when the pH was below 4.5, Acid dyes exhibited higher sorption rate constant and lower half dyeing time for the fibre than for spun silk and wool, which was related to the special morphological structure of the fibre, At pH 4, the sorption of disulphonated acid dyes with higher molecular weight followed the dual sorption mechanism of Langmuir plus Nernst-type partitioning well as they interacted with the fibre through electrostatic forces, hydrophobic forces and hydrogen bonds. It is considered that soybean protein and PVA components should be simultaneously dyed by disulphonated acid dyes with higher molecular weight.     

运用高收缩涤纶长丝开发机织物新品种

高收缩涤纶纤维在国内已研制成功,在国外运用极广,用量很大。本文探讨由物理法制得的高收缩涤纶长丝在机织物中的应用。讨论了纱线结构、织物组织、高收缩纤维含量、收缩率与织物密度的关系等问题。提出了仿制绉纱类轻薄丝织物、凹凸织物和中厚型仿毛织物的方法。