| 湿法脱硫系统中应用蒸汽相变技术脱除细颗粒 |
| |
| 引用本文： | 鲍静静,杨林军,颜金培,刘锦辉,宋士娟. 湿法脱硫系统中应用蒸汽相变技术脱除细颗粒[J]. 东南大学学报(自然科学版), 2009, 39(5). DOI: 10.3969/j.issn.1001-0505.2009.05.027 |
| |
| 作者姓名： | 鲍静静 杨林军 颜金培 刘锦辉 宋士娟 |
| |
| 作者单位： | 东南大学能源与环境学院,南京,210096 |
| |
| 基金项目： | 国家自然科学基金资助项目，国家高技术研究发展计划(863计划)资助项目 |
| |
| 摘 要： | 通过在脱硫塔进口烟气、塔内脱硫液进口上方添加适量蒸汽等措施,在湿法烟气脱硫(WFGD)系统中进行了利用蒸汽相变原理高效脱除细颗粒的试验研究.考察了采用CaCO3, Na2CO3, NH3·H2O等3种不同脱硫剂时,WFGD系统对细颗粒的脱除性能及其脱硫剂、蒸汽添加量、液气比(体积比)、脱硫塔进口气液温差等的影响,并进行了添加蒸汽和喷雾化水的对比试验.结果表明,由于形成无机盐气溶胶细颗粒,采用CaCO3, NH3·H2O脱硫剂时,WFGD系统对细颗粒的脱除效果明显差于Na2CO3脱硫剂;在WFGD系统中应用蒸汽相变原理可显著促进细颗粒的脱除,在蒸汽添加量为0.05 kg/m3时,细颗粒数浓度脱除效率可增至60%～70%以上;液气比的影响与脱硫塔内是否存在蒸汽相变有关;提高脱硫塔进口气液温差有利于细颗粒脱除;烟气温度较高时,利用雾化液滴的蒸发替代添加蒸汽也能显著促进细颗粒的脱除.
|
| 关 键 词： | 湿法烟气脱硫 细颗粒 脱除 蒸汽相变 |
Removal of fine particles in wet flue gas desulphurization system by heterogeneous condensation |
| |
| Bao Jingjing,Yang Linjun,Yan Jinpei,Liu Jinhui,Song Shijuan. Removal of fine particles in wet flue gas desulphurization system by heterogeneous condensation[J]. Journal of Southeast University(Natural Science Edition), 2009, 39(5). DOI: 10.3969/j.issn.1001-0505.2009.05.027 |
| |
| Authors: | Bao Jingjing Yang Linjun Yan Jinpei Liu Jinhui Song Shijuan |
| |
| Affiliation: | Bao Jingjing Yang Linjun Yan Jinpei Liu Jinhui Song Shijuan(School of Energy , Environment,Southeast University,Nanjing 210096,China) |
| |
| Abstract: | A novel process to remove fine particles with high efficiency by heterogeneous condensation in a wet flue gas desulphurization(WFGD) system is presented.A supersaturated vapor phase,necessary for condensational growth of fine particles,was achieved in the SO2 absorption zone and at the top of the wet FGD scrubber by adding steam in the gas inlet and above the scrubbing liquid inlet of the scrubber,respectively.The condensational grown droplets were then removed by the scrubbing liquid and a high-efficiency ... |
| |
| Keywords: | wet flue gas desulphurization fine particles removal heterogeneous condensation |
| 本文献已被 CNKI 万方数据 等数据库收录！ |
|
