STUDY ON THE ELEMENTAL CHLORINE FREE BLEACHING OF BAMBOO KRAFT PULP

1INTRODUCTIONChina is a country using the most variety of non-wood fiber raw material and is the largest country producing non-wood fiber pulp and paper in the world[1]. Bamboo is one kind of the main non-wood species for papermaking in China. Although the structure of raw materials for papermaking has being adjusted through increasing the proportion of wood pulp and by effectively utilizing waste paper source, non-wood species will still remain an important fiber resource[1,2].At present…     

桉木硫酸盐浆LMS生物漂白的研究

进行了桉木硫酸盐将漆酶一介体系统（LMS）生物漂白的研究,漆酶由白腐菌Panus conchatus固体发酵并分纯化而制得;一种新的介体－－N－羟基乙酰苯胺（NHA）自行合成,采用L／MQP漂白流程,仅用2％（质量分数）的H2O2就将桉木常规硫酸盐浆（EMCC－O）可达到87．6％ISO的白度,生物漂白的CK浆和EMCC－O浆的粘度都很高,说明漆酶／NHA生物漂白的脱木素选择性很好。     

ENZYMATIC BLEACHING OF WHEAT STRAW SODA-AQ PULP BY LMS TREATMENT

Laccase has been proven that it has a good selectivity and efficiency in pulp bleaching. In this paper, the effects of LMS (Laccase Mediator System) treatment on delignification and bleaching of wheat straw pulp at various conditions, such as laccase dosage,temperature, oxygen pressure and pH, were investigated. The TCF sequence including LMS can bleach the wheat straw pulp to 81% ISO brightness with good strength. The synergetic biobleaching of LMS and xylanase of wheat straw pulp was also investigated. It was found that the final brightness and strength of synergetic biobleaching pulps increased to a certain extent and the bleaching selectivity was improved. The combination of the enzymes is feasible for the delignification and bleaching.     

STUDY OF COORDINATED PRETREATMENT OF XYLANASE AND LACCASE ON SODA-AQ WHEAT STRAW PULP BEFORE CEH BLEACHING

INTRODUCTIONXylanase pretreatment can produce many small holes on pulp surfaces and cross section by removing part xylose that may be sucked back or exists in style of LCC. Thus penetrability of following chemicals. Olsen [1] observed coordinated pretreatment of xylanase and lignin enzyme (compound of lignin peroxide enzyme and manganese peroxide enzyme) had better delignification than sole xylanase and sole laccase lignin enzyme. So we can forecast that coordinated pretreatment of xylan…     

桉树制浆造纸性能的研究(第二报)——雷州半岛四种桉树浆的漂白试验

<正>对柠檬桉烧碱—蒽醌浆(AP+AQ)和硫酸盐浆(KP)进行了H单段,H—H两段,C—E—H三段以及C—E—H—D四段漂白试验。对雷林一号桉、草律桉、窿缘桉硫酸盐浆还做了H单段漂白性能的对比试验。结果表明:在用氯量7％、浆浓6％,温度40℃、时间3小时的H单段漂白条件下,柠檬桉(AP+AQ)和柠檬桉(KP)的白度均可达70度以上。采用C—E—H—D四段漂,用氯量为6％,柠檬桉(AP+AQ)的白度超过80度,D.P.在800以上。四种桉树中,雷林一号桉的漂白性能最好,窿缘桉最难漂白,草律桉与柠檬桉的漂白性能相近。柠檬桉、草律桉、雷林一号桉制得的漂白浆,物理强度甚好,裂断长6060—8050米,耐折度59—413次,可以用来生产一般文化用纸,也可考虑用来生产某些高级纸张。     

THE STUDY ON TCF BLEACHING OF NS REED PULP

In this paper, we have researched TCF bleaching on reed pulp including oxygen delignification, oxygen delignification with H2O2 intensification and H2O2 bleaching. The results show that Op-P bleaching process on NS reed pulp is suitable and the brightness of bleached pulp is up to 82% ISO.     

白腐菌改性桉木CTMP浆的漂白研究

利用白腐菌改性处理可以显著提高机械浆的强度性能,有利于拓宽机械浆的应用范围.本文采用白腐菌Trametes hirsute 196对桉木CTMP浆进行改性处理,并探讨了白腐菌处理后纸浆的漂白工艺.研究结果表明:白腐菌处理使桉木CTMP浆白度值从49.6%下降到37.8%,且这种改性后纸浆的可漂性较差,H2O2和Na2S2O4单段漂后纸浆白度均在60%以下,但采用Na2S2O4—H2O2两段组合漂白工艺可以使漂后Bio-CTMP浆白度达到71.3%.     

ENZYMATIC DEINKING OF OLD NEWSPRINT WITH CELLULASES AND XYLANASE

The enzymatic deinking and fiber modification of old newsprint (ONP) with several cellulases and xylanase were investigated and the suitable enzyme candidates were selected for ONP deinking in this paper. The results demonstrated that the cellulases and hemicellulases could significantly improve the deinking efficiency and fiber modification.Moreover, the synergistic effects of Novozym342 and xylanase (HC) can further enhance the deinking performance, reduce the dirt count and improve the brightness of resulting pulp. Additionally, compared to deinked pulps, obtained from conventional chemical materials, enzymatically deinked pulps had better bleachability, and the brightness of the bleached pulp reached 59.1% ISO, 9% ISO higher than the unbleached pulp.     

耐热木聚糖酶助漂针叶木硫酸盐浆的研究

探讨了嗜热真菌耐热木聚糖酶助漂针叶木硫酸盐浆的应用前景.着重研究了应用耐热木聚糖酶进行生物助漂的酶用量、酶处理的pH值以及漂白用氯量等影响因素.结果表明,在不影响纸浆的各项性能的情况下,经酶处理的纸浆白度相比对照增加1.06%~5.11%ISO.同时,酶处理纸浆漂白时可减少漂白用氯量.另外,在偏碱性条件下进行酶处理对纸浆漂白效果的影响较为显著.纸浆纤维的扫描电镜结果显示,酶未对纤维造成损伤,而是改善了纸浆纤维的可漂性.该耐热木聚糖酶非常适宜应用于酶助漂.     

过渡金属离子对废纸浆H2O2漂白的影响

研究了过渡金属离子对废纸浆H2O2漂白的影响.研究结果表明,经较强的螯合处理之后重新加Cu2 ,Fe2 和Mn2 ,漂后纸浆的白度降低,残余H2O2减少,漂白效率降低.     

马尾松化学预热机械浆镁碱过氧化氢漂白

研究了用镁碱代替钠碱的马尾松化学预热机械浆（CTMP）浆过氧化氢漂白工艺及其对纸浆性能的影响,分析了镁碱和钠碱过氧化氢漂白废液对环境的影响.试验结果表明,马尾松CTMP浆镁碱漂白过氧化氢的最佳漂白工艺条件为：H2O2体积浓度为4%,Mg（OH）2质量浓度为1.2%,Na2SiO3质量浓度为1.5%、漂白温度为80℃、漂白时间为120 min,其白度可至63.5%（ISO）,而经钠碱漂白后纸浆的白度值为61.4%（ISO）.镁碱过氧化氢漂白废液化学耗氧量（CODcr）为193.6 g/L,比钠碱过氧化氢漂白废液化学耗氧量（CODcr=312.86 g/L）降低了38.12%.     

改良木聚糖酶辅助漂白芦苇浆的工艺研究

采用分子改良后的木聚糖酶对芦苇浆进行生物预处理,考察了改良木聚糖酶辅助漂白的效果。结果表明,酶预处理可以降低CEH三段漂白中氯化C段的氯气用量60%。改良木聚糖酶预处理辅助漂白芦苇纸浆最佳条件为:pH为7.0,温度60℃,浆浓(质量分数)5%,酶用量12μmol/(min.g),预处理时间60 min。在此条件下C段氯用量降至对照的40%时,酶处理漂后样品白度可达到84.0%(ISO),高出对照样的白度3.7%(ISO)。改良木聚糖酶预处理还能够改善纸浆漂后样的物理性能。     

活化剂在麦草硫酸盐浆中无氯和少氯漂白中的应用

在麦草ＫＰ浆的无氯和少氯漂白程序中使用活化剂,可促进脱木素作用并提高浆的白度。在氧脱木素前用ＮＯ２,硫酸和过氧酸进行预处理比较,以ＮＯ２效果最佳。ＮＯ２用量２％,处理后浆的卡伯值比未处理降低了６％,白度提高４％,粘度只下降１．６％。在Ｄ／ＣＥＤＤ漂白程序中,漂前用对有效氯用量８％的Ｓ１２预处理,白度提高２．３％ＩＳＤ,粘度基本无变化;活化剂ＴＡ用于ＮＯＰ三段漂的Ｐ段,用量４％（对浆）,可提高白度４．３％ＩＳＯ,粘度也有明显提高。本试验采用ＧＯＰＡＰＴＡ无氯漂白程序,可使麦草ｋｐ浆漂后白度达８０％ＩＳＯ,但粘度下降较大     

THE TCF BLEACHING OF NS-AQ ASPEN HIGH YIELD CHEMICAL PULP

INTRODUCTIONNowadays, under the pressure of energy crisis, Methods押The pulp was put in the high-density polyethylene plastic bag in the of thermostatic water bath where the pulp was treated with chelated environment pollution and market competition, the pulp industry has being developed in the direction of "Three Highness" and " Three Lowness". "Three Highness" means high yield, high strength and high brightness; on the other hand, " Three Lowness" means low energy consumption, low wa…     

STUDY ON FORMAMIDINE SULPHINIC ACID BLEACHING OF POPLAR APMP

Bleaching of poplar APMP with Formamidine sulphinic acid (FAS) was investigated in this paper.The effects of FAS charges, ratio of treatment on the brightness gain, color reduction and pulp strength were studied. A single-stage FAS bleaching was optimized. Under the conditions of 10 % pulp consistency, 60 minutes time and 70℃ reaction temperature and 0.6 %, FAS (on 0.d.pulp), ratio of FAS to NaOH was 2, we produced a bleached pulp with a brightness of 62.3 %(SBD), a brightness gain of 9.2 units.     

蔗渣浆的全无氯漂白工艺

对蔗渣浆采用过氧化氢强化的氧脱木素(OP)-螯合预处理(Q)-压力过氧化氢漂白(PO)的短序漂白,探讨了将蔗渣浆漂至82%ISO和用非硅过氧化氢漂白稳定剂代替硅酸钠用于过氧化氢漂白的可行性.研究表明,非硅过氧化氢稳定剂PP-1与PP-2耐高温、耐高压,可用于压力过氧化氢漂白.OP段氢氧化钠用量为2.0%(相对于绝干浆质量,下同)、过氧化氢用量为0.5%,PO段过氧化氢用量为3.0%、PP-1用量为0.1%、PP-2用量为0.5%时,蔗渣浆采用OPQPO流程漂白后,浆的白度可达到85%ISO.而且OPQPO从根本上消除了可吸附有机卤化物的产生;经测定,漂白废水属于可生物降解废水.     

XYLANASE PREBLEACHING ON NaOH-AQ WHEAT STRAW PULP

INTRODUCTIONChina is a kingdom of straw pulps and wheat strawhas a dominant proportion in non-wood fiberresource. Wheat straw is inexhaustible annual plant.When it is used to make pulp and paper, there is noproblem of affecting afforestation and energyconsumption. In order to make full use of existedresource and make products of good quality witheffluent of low pollution loading, the study of wheatstraw pulp has realistic meaning. On the other hand,application of biotechnology has penetra…     

RELATIVE IMPORTANCE OF WOOD DENSITY AND CARBOHYDRATE CONTENT ON PULPING YIELD AND PRODUCT QUALITY

INTRODUCTIONPulp quality depends on wood quality and pulping process conditions. Wood quality is a result of forestry management practices and a combination of genetic, physical, anatomical and chemical characteristics of the wood [35]. Eucalypt pulps are desired for printing and writing and for tissue paper grades due to their anatomical and chemical characteristics. It has been shown that wood density exerts significant influence on pulp quality [21]. This parameter, together with volum…     

CHLORINE DIOXIDE BLEACHING OF NaOH-AQ WHEAT STRAW PULP

The influences of chlorine dioxide bleaching of NaOH-AQ wheat straw pulp were studied in this paper. The results showed that the optimal conditions were as follows: chlorine dioxide dosage 1.0%,initial pH 4.0, pulp consistency 8% and 70℃ for 150 minutes. Furthermore, some ways of rebuild the conventional CEH bleaching sequence were put forward, such as CED, DED, DCED, and we draw a conclusion that CED, DCED has higher bleaching efficiency than the CEH bleaching process.     

高得率竹浆中抽出物及其对过氧化氢漂白的影响

本文对一种高得率竹浆——慈竹磺化化机浆（SCMP）的抽出物及其对过氧化氢漂白的影响进行了研究。GC-MS研究结果表明慈竹SCMP抽出物中主要成分是脂肪酸类和甾醇类物质，以及部分在紫外区330nm左右产生吸收的物质。抽提处理后漂白纸浆白度可提高6%~9 %ISO，热诱导返黄程度降低，CIE76色度也有很大改善。