回火温度对高Cr马氏体耐热钢组织与性能的影响

利用光学显微镜(OM)、透射电镜(TEM)、扫描电镜(SEM)及电子探针(EPMA)等手段,系统研究了不同回火温度下9%Cr马氏体耐热钢的组织及力学性能变化.结果表明:回火后位错网络化、析出相形态、板条马氏体破碎化等是影响力学性能变化的主要因素.正火并760℃回火后在室温和550℃条件下抗拉强度分别达到657和556MPa,0℃冲击功达到285J,此回火温度下实验钢具有最佳综合力学性能.700, 820,850℃回火,韧性大幅降低.高温服役条件下不发生粗化的MX相弥散分布在铁素体和马氏体中,与马氏体高温回复形成的亚稳态多边形结构有效提升耐热钢抗高温蠕变性能.     

正火对高Cr马氏体耐热钢组织和性能的影响

通过光学显微镜、透射电镜(TEM)及扫描电镜(SEM)分析,研究了正火处理对高Cr马氏体耐热钢显微组织、力学性能及断裂机理的影响.结果表明,900~970℃正火后,晶粒尺寸十分细小,在10μm以下.1060~1200℃正火晶粒尺寸迅速增长,1060℃正火晶粒尺寸约为33μm.经过1060℃×2h正火+760℃×3h回火热处理后,室温和600℃高温拉伸屈服强度分别达到535MPa和380MPa,综合力学性能优良,而1060℃长时间正火对力学性能并无明显影响.1060℃×2h正火+760℃×3h回火热处理后得到破碎的晶粒细小回火马氏体组织,晶界上200~300nm M₂₃C₆和晶内5~50nm MX型弥散析出有效地阻碍位错运动,进而提高了材料力学性能.     

SiMnCr系高强度钢组织转变研究

对SiMnCr试验用钢,分别进行了淬火、等温淬火和空冷处理,并分别利用金相显微镜、扫描电子显微镜和透射电子显微镜进行了显微组织观察,测定了CCT曲线.淬火态下获得板条马氏体和其间的残余奥氏体薄膜组织,等温淬火得到准贝氏体组织,锻造空冷状态下得到以板条马氏体为主含贝氏体和少量位于板条间界的残余奥氏体薄膜复合组织,经300℃回火,无渗碳体析出.     

V、Ta微合金化12Cr低活性F/M钢的优化设计

采用Thermo-Calc热力学模拟计算与实验相结合的方法,优化设计了一种V、Ta微合金化的低活性F/M钢12Cr3WVTa,经1 050℃水淬及780℃回火后对其显微组织及析出相进行光学显微镜、扫描电镜和透射电镜观察以及能谱分析.实验钢淬火回火后显微组织由回火马氏体和少量δ铁素体相组成,析出相主要为M23C6和MX相(M=V,Ta;X=C,N),其中M23C6主要分布于回火马氏体板条界和相界,而MX弥散析出于回火马氏体板条内以及δ铁素体内.实验钢室温和高温(600℃)拉伸力学性能良好,600℃下材料抗拉强度为507 MPa,屈服强度为402 MPa,满足超临界水冷堆用包壳管的拉伸性能要求.     

SiMnCr系高强度钢组织转变研究

对SiMnCr试验用钢，分别进行了淬火、等温淬火和空冷处理，并分别利用金相显微镜，扫描电子显微镜和透射电子显微镜进行了显微组织观察，测定了CCT曲线，淬火态下获得板条马氏体和其间的残余奥氏体薄膜组织，等温淬火得到贝氏体组织，锻造空冷状态下得到的以板条马氏体为主含贝氏体和少量位于板条间界的残余奥氏体薄膜复合组织，经300℃回火，无渗碳体析出。     

低温压力容器钢回火过程组织转变规律

以07MnNiMoVDR钢为研究对象,通过热膨胀试验、TEM检测相结合的方法,研究其回火过程中各回火温度区间中组织转变和碳化物析出的变化规律.结果表明:300℃回火时,残余奥氏体分解,片状θ-碳化物位于仍具有较高位错密度的α相板条之间;650℃回火时,α相除回复外,部分α相还发生了再结晶,析出物分布于已回复的板条之间以及再结晶晶界上.     

Fe-W-Cr耐热钢时效组织的研究

对目前正任试用的Fe-W-Cr 耐热钢用金相、电子金相、X-光、热膨振、电阻等方法作了研究,研究表明:该钢和合金有α-γ相变,从1150℃左右淬火下来的组织为铁素体+马氏体。700℃时效时,从α品粒中析出 Laves 相,同时马氏体分解析出碳化物(有M_(23)G6,M_6C和M_7C_3等).钢中起强化作用的是 Laves 相,它在700℃比较稳定。     

Fe-13Cr-5Ni马氏体不锈钢在连续加热过程中两相区的奥氏体生长行为

通过光学显微镜、透射电子显微镜、X射线衍射仪以及显微硬度仪研究Fe-13Cr-5Ni马氏体不锈钢在加热过程中的组织转变行为.结果表明,Fe-13Cr-5Ni钢在10℃·s-1的加热速率下,加热至奥氏体单相区,冷却至室温后具有明显的“组织遗传”现象.奥氏体以“针状”形式在马氏体板条界处形核并沿着马氏体板条界长大,与母相间保持Kurdjumov-Sachs(K-S)位向关系.加热至两相区不同温度然后淬火至室温,奥氏体的量随两相区保温温度的升高先增加再减少,650℃时对应室温下残余奥氏体的极大值,并且这一变化趋势与试样显微硬度测试结果所得结论一致.     

调质低碳贝氏体钢的组织和性能

研究了C--Mn--Mo--Cu--Nb--Ti--B系低碳微合金钢915℃淬火和490～640℃回火的调质工艺对钢的组织及力学性能的影响.用扫描电镜和透射电镜对实验钢的组织、析出物形态和分布以及断口形貌进行观察,采用X射线衍射仪分析钢中残余奥氏体的体积分数.结果表明:调质后,实验钢获得贝氏体、少量马氏体及残余奥氏体复相组织,贝氏体板条宽度只有250 nm,残余奥氏体的体积分数随着回火温度的升高而降低,经淬火与520℃回火后残余奥氏体的体积分数为2.1%.调质后析出物的数量激增,6～15 nm的析出物占70%以上.实验钢经过915℃淬火与520℃回火后,其屈服强度达到915 MPa,抗拉强度990 MPa,-40℃冲击功为95 J.细小的析出物及窄的板条提高了钢的强度.板条间有残余奥氏体存在,改善了实验钢的韧性.     

T92锅炉钢649℃长期时效的微观组织研究

T92锅炉钢是用V、Nb元素微合金化的9Cr-0.5Mo-1.8W-VNb铁素体钢.本文研究了T92钢在649℃下经过1000、3000、5000和8000h不同时间的长期时效的微观组织的变化,并与其原始状态的微观组织进行了比较,发现随着时效时间的延长碳化物析出数量增加、尺寸略长大 碳化物类型主要为M23C6,而MX和Laves含量很少 板条状的基体组织形貌在长期时效过程中变化不大,即使经过649℃,8000h时效,仍保留板条马氏体的形貌.     

Markedness and its Interpretation in Language Use

Language markedness is a common phenomenon in languages, and is reflected from hearing, vision and sense, i.e. the variation in the three aspects such as phonology, morphology and semantics. This paper focuses on the interpretation of markedness in language use following the three perspectives, i.e. pragmatic interpretation, psychological interpretation and cognitive interpretation, with an aim to define the function of markedness.     

Features of Women's language

Language is a means of verbal communication. People use language to communicate with each other. In the society, no two speakers are exactly alike in the way of speaking. Some differences are due to age, gender, statue and personality. Above all, gender is one of the obvious reasons. The writer of this paper tries to describe the features of women＇s language from these perspectives： pronunciation, intonation, diction, subjects, grammar and discourse. From the discussion of the features of women＇s language, more attention should be paid to language use in social context. What＇s more, the linguistic phenomena in a speaking community can be understood more thoroughly.     

An Analysis of Catherine＇s Character——Wuthering Heights

Wuthering Heights, Emily Bronte＇s only novel, was published in December of 1847 under the pseudonym Ellis Bell. The book did not gain immediate success, but it is now thought one of the finest novels in the English language. Catherine is the key character of this masterpiece, because everybody and everything center on her though she had a short life. We can understand this masterpiece better if we know Catherine well.     

Lower Paleozoic oil relationships within Williston Basin, Canada

The Williston Basin is a significant petroleum province, containing oil production zones that include the Middle Cambrian to Lower Ordovician, Upper Ordovician, Middle Devonian, Upper Devonian and Mississippian and within the Jurassic and Cretaceous. The oils of the Williston Basin exhibit a wide range of geochemical characteristics defined as "oil families", although the geochemical signature of the Cambrian Deadwood Formation and Lower Ordovician Winnipeg reservoired oils does not match any "oil family". Despite their close stratigraphic proximity, it is evident that the oils of the Lower Palaeozoic within the Williston Basin are distinct. This suggests the presence of a new "oil family" within the Williston Basin. Diagnostic geochemical signatures occur in the gasoline range chromatograms, within saturate fraction gas chromatograms and biomarker fingerprints. However, some of the established criteria and cross-plots that are currently used to segregate oils into distinct genetic families within the basin do not always meet with success, particularly when applied to the Lower Palaeozoic oils of the Deadwood and Winnipeg Formation.     

低渗透非均质砂岩油藏启动压力梯度研究

理论推导与室内实验相结合,建立了低渗透非均质砂岩油藏启动压力梯度确定方法。首先借助油藏流场与电场相似的原理,推导了非均质砂岩油藏启动压力梯度计算公式。其次基于稳定流实验方法,建立了非均质砂岩油藏启动压力梯度测试方法。结果表明:低渗透非均质砂岩油藏的启动压力梯度确定遵循两个等效原则。平面非均质油藏的启动压力梯度等于各级渗透率段的启动压力梯度关于长度的加权平均;纵向非均质油藏的启动压力梯度等于各渗透率层的启动压力梯度关于渗透率与渗流面积乘积的加权平均。研究成果可用于有效指导低渗透非均质砂岩油藏的合理井距确定,促进该类油藏的高效开发。     

On Tragic Consciousness In The Works By Ernest Hemingway

As an American modern novelist who were famous in the literary world, Hemingway was not a person who always followed the trend but a sharp observer. At the same time, he was a tragedy maestro, he paid great attention on existence, fate and end-result. The dramatis personae's tragedy of his works was an extreme limit by all means tragedy on the meaning of fearless challenge that failed. The beauty of tragedy was not produced on the destruction of life, but now this kind of value was in the impact activity. They performed for the reader about the tragedy on challenging for the limit and the death.     

Achieving Unusual States of Matter Under High Pressure

正The periodicity of the elements and the non-reactivity of the inner-shell electrons are two related principles of chemistry,rooted in the atomic shell structure.Within compounds,Group I elements,for example,invariably assume the+1 oxidation state,and their chemical properties differ completely from those of the p-block elements.These general rules govern our understanding of chemical structures and reactions.Using first principles calcula-     

Exchange-Correlation and Electronic Excitation Energies from Pairing Matrix Fluctuations

We have developed an adiabatic connection to formulate the ground-state exchange-correlation energy in terms of pairing matrix linear fluctuations.This formulation of the exchange-correlation energy opens a new channel for density functional approximations based on the many-body perturbation theory.We illustrate the potential of such approaches with an approximation based on the particle-particle Random Phase Approximation(pp-RPA).This re-     

Density Functional Theory for the Response of Periodic Systems to Electric Fields Based on the Vector Potential Approach

正The electronic and nuclear(structural/vibrational)response of 1D-3D nanoscale systems to electric fields gives rise to a host of optical,mechanical,spectral,etc.properties that are of high theoretical and applied interest.Due to the computational difficulty of treating such large systems it is convenient to model them as infinite and periodic(at least,in first approximation).The fundamental theoretical/computational problem in doing so is that     

Call for Papers

<正>"The Journal of Shanghai Normal University:Mathematics"is published by Shanghai Normal University as regular issues of The Journal of Shanghai Normal University each year from 2014 in English.The editors-in-chief of the issues are professors Yuhao Cong and Maoan Han.The Journal of Shanghai Normal University was started in 1958 with