紫金山铜矿浸出过程黄铁矿的氧化行为

针对紫金山铜矿堆浸过程中,在辉铜矿和铜蓝等有用矿物浸出的同时,有黄铁矿被大量浸出,造成浸出液中Fe3 浓度过高的现状,研究了细菌浸出黄铁矿的氧化行为和机理,重点考察了Fe3 的化学氧化以及细菌浸出黄铁矿过程的影响因素.研究结果表明,在有菌条件下,pH值为1.6时,混合矿浸出初期,黄铁矿的浸出率仅为5%～8%;随着浸出时间的增加,氧化还原电位升高,浸出15d后,氧化还原电位上升到500mV以上时,黄铁矿的浸出率可达25%.说明氧化还原电位是细菌浸出黄铁矿过程的重要影响因素.机理研究表明,细菌浸出黄铁矿是以间接反应为主,细菌在黄铁矿表面的吸附对黄铁矿的浸出具有协同作用.     

Use of mesophilic and thermophilic bacteria for the improvement of copper extraction from a low-grade ore

Bioleaching was examined for copper extraction from a low grade ore using mesophilic and moderate thermophilic bacteria. Five equal size columns were used for the leaching of the ore. Sulfuric acid solution with a flow rate of 3.12 L·m-2·h-1 and pH 1.5 passed through each column continuously for 90 d. In the first and the second column, bioleaching was performed without agglomeration of the ore and on the agglomerated ore, respectively. 28wt% of the copper was extracted in the first column after 40 d, while this figure was 38wt% in the second column. After 90 d, however, the overall extractions were almost the same for both of them. Bioleaching with mesophilic bacteria was performed in the third column without agglomeration of the ore and in the fourth column on the agglomerated ore. After 40 d, copper extractions in the third and the fourth columns were 62wt% and 70wt%, respectively. Copper extractions were 75wt% for both the columns after 90 d. For the last column, bioleaching was performed with moderate thermophilic bacteria and agglomerated ore. Copper extractions were 80wt% and 85wt% after 40 and 90 d, respectively. It was concluded that crushing and agglomeration of the ore using bacteria could enhance the copper extraction considerably.     

采用氧化焙烧-酸浸法从高碳石煤中提钒试验研究

针对广西某难浸高碳石煤,比较相同焙烧和酸浸条件下静态焙烧矿和流态化焙烧矿钒的浸出率,优化流态化焙烧矿的酸浸条件。研究结果表明:流态化焙烧矿酸浸钒的浸出率比静态焙烧矿酸浸钒的浸出率平均高24%,所以,在相同焙烧温度、时间下流态化焙烧较静态焙烧更利于钒的浸出;在液固质量比为0.8:1.0,二氧化锰添加量为3%和氢氟酸添加量为2%的条件下,得最佳酸浸条件,即酸矿质量比为0.4:1.0,浸出温度为150℃,浸出时间为6 h,在此最佳酸浸条件下,钒浸出率可达88.26%。     

Extraction of vanadium from high calcium vanadium slag using direct roasting and soda leaching

The extraction of vanadium from high calcium vanadium slag was attempted by direct roasting and soda leaching. The oxidation process of the vanadium slag at different temperatures was investigated by X-ray diffraction (XRD), scanning electron microscopy (SEM), and energy dispersive spectroscopy (EDS). The effects of roasting temperature, roasting time, Na₂CO₃ concentration, leaching temperature, leaching time, and liquid to solid ratio on the extraction of vanadium were studied. The results showed that olivine phases and spinel phases in the vanadium slag were completely decomposed at 500 and 800℃, respectively. Vanadium-rich phases were formed at above 850℃. The leaching rate of vanadium reached above 90% under the optimum conditions:roasting temperature of 850℃, roasting time of 60 min, Na₂CO₃ concentration of 160 g/L, leaching temperature of 95℃, leaching time of 150 min, and liquid to solid ratio of 10:1 mL/g. The main impurities were Si and P in the leach liquor.     

Zinc bioleaching from an iron concentrate using Acidithiobacillus ferrooxidans strain from Hercules Mine of Coahuila,Mexico

The iron concentrate from Hercules Mine of Coahuila,Mexico,which mainly contained pyrite and pyrrhotite,was treated by the bioleaching process using native strain Acidithiobacillus ferrooxidans (A.ferrooxidans) to determine the ability of these bacteria on the leaching of zinc.The native bacteria were isolated from the iron concentrate of the mine.The bioleaching experiments were carried out in shake flasks to analyze the effects of pH values,pulp density,and the ferrous sulfate concentration on the bioleaching process.The results obtained by microbial kinetic analyses for the evaluation of some aspects of zinc leaching show that the native bacteria A.ferrooxidans,which is enriched with a 9K Silverman medium under the optimum conditions of pH 2.0,20 g/L pulp density,and 40 g/L FeSO4,increases the zinc extraction considerably observed by monitoring during15 d,i.e.,the zinc concentration has a decrease of about 95% in the iron concentrate.     

Effects of the mineral phase and valence of vanadium on vanadium extraction from stone coal

The influence of roasting on the leaching rate and valence of vanadium was evaluated during vanadium extraction from stone coal. Vanadium in stone coal is hard to be leached and the leaching rate is less than 10% when the raw ore is leached by 4 mol/L H₂SO₄ at 90℃ for 2 h. After the sample is roasted at 900℃ for 2 h, the leaching rate of vanadium reaches the maximum, and more than 70% of vanadium can be leached. The crystal of vanadium-bearing mica minerals decomposes and the content of V(V) increases with the rise of roasting temperature from 600 to 900℃, therefore the leaching rate of vanadium increases significantly with the decomposition of the mica minerals. Some new phases, anorthite for example, form when the roasting temperature reaches 1000℃. A part of vanadium may be enwrapped in the sintered materials and newly formed phases, which may impede the oxidation of low valent vanadium and make the leaching rate of vanadium drop dramatically. The leaching rate of vanadium is not only determined by the valence state of vanadium but also controlled by the decomposition of vanadium-bearing minerals and the existence state of vanadium to a large extent.     

Microemulsion leaching of vanadium from sodium-roasted vanadium slag by fusion of leaching and extraction processes

The fusion of the leaching and purification processes was realized by directly using microemulsion as the leaching agent. The bis-(2-ethyhexyl) phosphoric acid(DEHPA)/n-heptane/Na OH microemulsion system was established to directly leach vanadates from sodium-roasted vanadium slag. The effect of the leaching agent on the leaching efficiency was investigated, in addition to the molar ratio of H_2O/Na DEHP(W), DEHPA concentration, solid/liquid ratio, stirring time, and leaching temperature. In optimal situations, the vanadium leaching efficiency reaches 79.57%. The X-ray diffraction characterization of the leaching residue and the Raman spectrum of the microemulsion before and after leaching demonstrate the successful entry of vanadates from the sodium-roasted vanadium slag into the microemulsion. The proposed method successfully realizes the leaching and purification of vanadates in one step, thereby greatly reducing production costs and environmental pollution. It also offers a new way to achieve the green recovery of valuable metals from solid resources.     

不同钙化剂对高钒渣酸浸提钒的影响

针对传统钒渣钠化焙烧-水浸提钒工艺的不足,确定对钒渣钙化焙烧-酸浸提钒进行研究。在理论分析的基础上,本研究以高钒渣为原料,研究了钙化焙烧-酸浸提钒过程中3种钙化剂(CaSO4、CaCO3、CaO)的焙烧机理以及对提钒效果的影响。研究结果表明:钒浸出率随焙烧温度的升高先增大后减小,且在1 450K时达到最大值;钙化剂配比为100%CaSO4时提钒率最大;在目前实验室研究条件下,钒的浸出率最大可达93.53%。     

Zinc bioleaching from an iron concentrate using <Emphasis Type="Italic">Acidithiobacillus ferrooxidans</Emphasis> strain from Hercules Mine of Coahuila,Mexico

The iron concentrate from Hercules Mine of Coahuila, Mexico, which mainly contained pyrite and pyrrhotite, was treated by the bioleaching process using native strain Acidithiobacillus ferrooxidans (A. ferrooxidans) to determine the ability of these bacteria on the leaching of zinc. The native bacteria were isolated from the iron concentrate of the mine. The bioleaching experiments were carried out in shake flasks to analyze the effects of pH values, pulp density, and the ferrous sulfate concentration on the bioleaching process. The results obtained by microbial kinetic analyses for the evaluation of some aspects of zinc leaching show that the native bacteria A. ferrooxidans, which is enriched with a 9K Silverman medium under the optimum conditions of pH 2.0, 20 g/L pulp density, and 40 g/L FeSO₄, increases the zinc extraction considerably observed by monitoring during15 d, i.e., the zinc concentration has a decrease of about 95% in the iron concentrate.     

Thin-layer heap bioleaching of copper flotation tailings containing high levels of fine grains and microbial community succession analysis

Thin-layer heap bioleaching of copper flotation tailings containing high levels of fine grains was carried out by mixed cultures on a small scale over a period of 210 d. Lump ores as a framework were loaded at the bottom of the ore heap. The overall copper leaching rates of tailings and lump ores were 57.10wt% and 65.52wt%, respectively. The dynamic shifts of microbial community structures about attached microorganisms were determined using the Illumina MiSeq sequencing platform based on 16S rRNA amplification strategy. The results indicated that chemolithotrophic genera Acidithiobacillus and Leptospirillum were always detected and dominated the microbial community in the initial and middle stages of the heap bioleaching process; both genera might be responsible for improving the copper extraction. However, Thermogymnomonas and Ferroplasma increased gradually in the final stage. Moreover, the effects of various physicochemical parameters and microbial community shifts on the leaching efficiency were further investigated and these associations provided some important clues for facilitating the effective application of bioleaching.     

Synergistic effect of microwave irradiation and CaF<Subscript>2</Subscript> on vanadium leaching

The effect and mechanism of microwave irradiation on vanadium leaching were studied via a comparison between microwave heating and conventional heating. The results show a synergistic effect of microwave irradiation and calcium fluoride (CaF₂) on the vanadium leaching efficiency. It is confirmed that the vanadium leaching process can be improved by microwave irradiation when CaF₂ is present. The leaching rate of vanadium under microwave irradiation is increased by 8%-15% when 5wt% CaF₂ is added; by contrast, in the absence of CaF₂, the leaching rate is almost unaffected compared to that by conventional heating. Morphological analysis reveals that the particles are gradually eroded by acid under microwave irradiation, whereas some of the fine particles in samples subjected to conventional heating are tightly covered by a flocculent silicate product. Moreover, a large amount of Al and V and a small amount of Si are dissolved from samples under microwave heating, as revealed by the elemental analysis of leachates. Fourier transform infrared spectroscopic analysis also indicates a higher mass transfer coefficient in the diffusion layer of the raw material by microwave irradiation. When CaF₂ is present, the reaction energy barrier is lowered and the leaching process is controlled by the tightly covered product layer, resulting in a prominent effect of microwave irradiation.     

pH值对浸矿细菌的活化以及金精矿脱砷的影响

通过在摇瓶中设定6个不同初始pH值梯度1.3,1.5,1.7,1.8,1.9,2.1,对细菌的活化以及高砷金精矿的脱砷浸出进行了研究.细菌活化阶段,HQ-0211菌在pH值1.3~1.9范围更加适应,活化速度快,氧化效果好.高砷金精矿细菌脱砷阶段,初始pH值在1.7~1.9范围最利于细菌浸矿,停滞期短,氧化速度快.初始pH值较高,为2.1时,细菌会较快进入衰亡期,不适于细菌浸矿.初始pH值较低,为1.3~1.5时,细菌适应停滞期长,氧化脱砷速度缓慢.     

低品位原生金矿的生物柱浸

采用粘结剂S-11将某低品位原生金矿的精矿粘结包裹在其原矿矿石上进行生物柱浸与原矿生物柱浸的对比研究.主要研究了生物柱浸过程中Fe2+浓度,pH,Eh,矿石表面吸附的细菌及菌液中游离细菌数量的变化、矿石的脱砷率、脱硫率,生物柱浸后矿石金的氰化浸出率.结果表明:金精矿包裹后的矿石表面因含硫化矿物较多,更适合细菌的吸附与繁殖;包裹生物柱浸120 d后矿石的脱砷率为70.14%,脱硫率为41.26%,金的氰化浸出率为81.21%,比传统生物柱浸矿石的脱砷率、脱硫率和浸金率分别高24.01%,19.11%和21.48%.包裹生物柱浸对矿石的氧化效果明显.     

钒渣无焙烧浸出液中钒铁萃取分离

利用本课题组提出的钛白废酸无焙烧加压浸出钒渣提钒的新技术,以P204为萃取剂从废酸浸出钒渣的浸出液中进行了提钒研究.实验结果表明:采用亚硫酸钠为浸出液预处理还原剂,将浸出液中三价铁还原成二价铁,从而防止三价铁的共萃;常温条件下,当浸出液初始p H=2.5、水相与有机相体积比为1∶3,震荡时间为4 min时,采用有机相组成为20%P204及10%TBP协同萃取体系,钒的萃取率可达98.61%以上,钒铁的分离系数可达135.3.     

Leaching of vanadium,sodium, and silicon from molten V-Ti-bearing slag obtained from low-grade vanadium-bearing titanomagnetite

The water leaching process of vanadium, sodium, and silicon from molten vanadium-titanium-bearing (V-Ti-bearing) slag obtained from low-grade vanadium-bearing titanomagnetite was investigated systematically. The results show that calcium titanate, sodium aluminosilicate, sodium oxide, silicon dioxide and sodium vanadate are the major components of the molten V-Ti-bearing slag. The experimental results indicate that the liquid-solid (L/S) mass ratio significantly affects the leaching process because of the respective solubilities and diffusion rates of the components. A total of 83.8% of vanadium, 72.8% of sodium, and 16.1% of silicon can be leached out via a triple counter-current leaching process under the optimal conditions of a particle size below 0.074 mm, a temperature of 90°C, a leaching time of 20 min, an L/S mass ratio of 4:1, and a stirring speed of 300 r/min. The kinetics of vanadium leaching is well described by an internal diffusion-controlled model and the apparent activation energy is 11.1 kJ/mol. The leaching mechanism of vanadium was also analyzed.     

PDP玻璃中金属锌的环境溶出特性

通过BCR三步逐级提取法、TCLP程序和DTPA及EDTA生物可利用性提取法,对废弃等离子显示屏玻璃中金属锌的环境溶出特性进行研究。结果表明:废弃PDP玻璃前、后板中Zn的化学形态均以可交换与弱酸溶解态和可还原态为主,前板中可氧化态Zn含量高于残渣态,后板中则残渣态Zn含量高于可氧化态Zn含量。废弃PDP玻璃具有较高的环境浸出毒性,其中,Zn的高浸出毒性主要是由可交换与弱酸溶解态和可还原态决定的,前、后板中这2种形态Zn的浸出量分别占其浸出总量的91.06%和96.79%,而可氧化态和残渣态对其TCLP浸出毒性贡献不大。废弃PDP玻璃中Zn的生物有效提取绝对量较高,其中,后板中Zn的EDTA提取量高达812.17mg/kg,废弃PDP玻璃潜在的生物可利用性非常高。     

酸浸法提钒新工艺的研究

研究了用稀硫酸直接浸出—萃取—反萃—氨水沉钒—煅烧的提钒工艺。结果表明,采用稀硫酸直接浸出,原矿渣中总钒的一次浸取率可达95%以上;用萃取-反萃方式净化和浓缩浸出液,同时使用萃取促进剂处理酸浸液,使萃取效率比传统方法有明显提高,萃取级数大大减少;沉钒步骤摒弃了传统的铵盐沉钒工艺,使用氨水直接沉钒,提高了产品的纯度。钒的总回收率达86%以上,比传统提钒工艺效率提高了20%以上,同时由于避免了焙烧从而解决了传统提钒过程中因焙烧等产生的HCl、Cl₂等污染问题。     

Extraction of vanadium from vanadium slag by high pressure oxidative acid leaching

To extract vanadium in an environment friendly manner, this study focuses on the process of leaching vanadium from vanadium slag by high pressure oxidative acid leaching. Characterizations of the raw slag, mineralogy transformation, and the form of leach residues were made by X-ray diffraction, scanning electron microscopy, and energy dispersive X-ray spectroscopy. The result shows that the vanadium slag is composed of major phases of fayalite, titanomagnetite, and spinel. During the high pressure oxidative acid leaching process, the fayalite and spinel phases are gradually decomposed by sulfuric acid, causing the release of vanadium and iron in the solution. Meanwhile, unreacted silicon and titanium are enriched in the leach residues. With the initial concentration of sulfuric acid at 250 g·L-1, a leaching temperature of 140℃, a leaching time of 50 min, a liquid-solid ratio of 10:1 mL·g-1, and oxygen pressure at 0.2 MPa, the leaching rate of vanadium reaches 97.69%.     

A method for recovery of iron,titanium, and vanadium from vanadium-bearing titanomagnetite

An innovative method for recovering valuable elements from vanadium-bearing titanomagnetite is proposed. This method involves two procedures:low-temperature roasting of vanadium-bearing titanomagnetite and water leaching of roasting slag. During the roasting process, the reduction of iron oxides to metallic iron, the sodium oxidation of vanadium oxides to water-soluble sodium vanadate, and the smelting separation of metallic iron and slag were accomplished simultaneously. Optimal roasting conditions for iron/slag separation were achieved with a mixture thickness of 42.5 mm, a roasting temperature of 1200℃, a residence time of 2 h, a molar ratio of C/O of 1.7, and a sodium carbonate addition of 70wt%, as well as with the use of anthracite as a reductant. Under the optimal conditions, 93.67% iron from the raw ore was recovered in the form of iron nugget with 95.44% iron grade. After a water leaching process, 85.61% of the vanadium from the roasting slag was leached, confirming the sodium oxidation of most of the vanadium oxides to water-soluble sodium vanadate during the roasting process. The total recoveries of iron, vanadium, and titanium were 93.67%, 72.68%, and 99.72%, respectively.     

土著微生物对尾矿中重金属的淋滤研究

生物淋滤对尾矿的重金属污染处理的效果已经得到了广泛的认可.在对酸性尾矿中的土著氧化硫硫杆菌以及氧化亚铁硫杆菌进行分离以及加富培养的基础上,分别运用单一菌种以及混合菌种对尾矿样本进行淋滤处理.通过12 d的淋滤实验,实验室结果表明,分离出的氧化亚铁硫杆菌以及氧化硫硫杆菌等土著微生物具有较高的利用价值.同时实验表明,在采用...