低品位原生金矿的生物柱浸

采用粘结剂S-11将某低品位原生金矿的精矿粘结包裹在其原矿矿石上进行生物柱浸与原矿生物柱浸的对比研究.主要研究了生物柱浸过程中Fe2+浓度,pH,Eh,矿石表面吸附的细菌及菌液中游离细菌数量的变化、矿石的脱砷率、脱硫率,生物柱浸后矿石金的氰化浸出率.结果表明:金精矿包裹后的矿石表面因含硫化矿物较多,更适合细菌的吸附与繁殖;包裹生物柱浸120 d后矿石的脱砷率为70.14%,脱硫率为41.26%,金的氰化浸出率为81.21%,比传统生物柱浸矿石的脱砷率、脱硫率和浸金率分别高24.01%,19.11%和21.48%.包裹生物柱浸对矿石的氧化效果明显.     

多金属氧化钼矿工艺矿物学及其综合利用技术研究

对氧化钼矿的工艺矿物学特征及其综合利用技术进行研究.结果表明:氧化钼矿的主要矿物组成为钼华、钼钙矿、褐铁矿、黄铁矿及石英.在磨矿细度为200目以下含量65%时,采用混合浮选工艺,可得钼品位为7.41%的钼精矿,钼回收率为82.18%,其中含铅18.02%、含金7.96 g.t-1、含银1 002 g.t-1;采用联合碱浸法处理钼精矿,可获得钼浸出率为95.61%的工艺指标;采用氰化法处理碱浸渣,金银浸出率分别为94.55%、83.96%;采用浮选法处理氰化渣,可得铅品位为46.76%的铅精矿,铅回收率为52.83%;采用重选法回收浮选尾矿中的石英,可获得SiO2含量为97.12%、回收率为80.84%的石英产品.     

玉米秸秆还原浸出高铁低品位锰矿研究

采用"玉米秸秆硫酸预处理—浸出"工艺处理含Mn 9.63%(质量分数)的朝阳锰矿.通过试验考察用硫酸对玉米秸秆进行预处理的时间、秸秆用量、温度、硫酸浓度和浸出温度对锰浸出率的影响.试验表明,在秸秆用量2.5 g、时间10 min、硫酸浓度1.2 mol/L、温度80℃时预处理秸秆,浸出温度为90℃的条件下,锰的浸出率达92%,杂质铁溶出率仅为20%.玉米秸秆处理前后FTIR分析结果表明,对秸秆进行硫酸预处理能够破坏难降解的木质素结构,有利于提高锰的浸出效果.     

Process mineralogy characteristics of acid leaching residue produced in low-temperature roasting-acid leaching pretreatment process of refractory gold concentrates

To provide a theoretical basis for a suitable process to extract gold from refractory gold concentrates, process mineralogy on the acid leaching residue of gold calcine was studied by chemical composition, X-ray diffraction, scanning electron microscopy-energy spectrum, and mineral dissociation analysis. The results showed that the acid leaching residue contained Au 68.22 g/t, Ag 92.71 g/t, Fe 0.44%, As 0.10%, and S 0.55%. Gold and silver minerals existed as native gold, argentite, and proustite. Quartz, the main gangue mineral, accounted for 78.33wt/%. The dissociation degree analysis showed that the proportions of monomer and exposed gold in acid leaching residue were 96.66wt%. The cyanidation results showed that the cyanide gold leaching rate of acid leaching residues was close to 100wt%. However, the maximum cyanide gold leaching rate of gold calcine was only 85.31wt%. This suggests that acid leaching can increase the gold dissolution rate in the cyanide process.     

A new process of extracting vanadium from stone coal

A new process of extracting vanadium from the stone coal vanadium ore in Fangshankou, Dunhuang area of Gansu Province, China was introduced. Various leaching experiments were carried out, and the results show that the vanadium ore in Fangshankou is difficult to process due to its high consumption of acid and the high leaching rate of impurities. However, the leaching rate can be up to 80% and the content of V₂O₅ in the residue can be between 0.22%–0.25% in the process of ore fine grinding→oxidation roasting→mixing and ripening→aqueous leaching→P₂O₄ solvent extraction→sulfuric acid stripping→oxidation and precipitation→decomposition by heat. Also, the quality of flaky V₂O₅ produced by this process can meet the requirements of GB3283–87. The total leaching rate of vanadium is 70%. Also, three types of wastes are easy to treat. The vanadium extraction process is better in relation to the aspect of environmental protection than the sodium method.     

低品位双重难处理金矿石工艺矿物学及浸金影响因素

试验所用矿石来自我国云南某金矿,该矿含金2.4 g/t,砷0.97%,碳1.47%.它是典型的低品位含碳双重难处理金矿石,浮选精矿-氰化提金,金浸出率为10.43%;浮选精矿-焙烧-氰化工艺,金浸出率为46.52%,属于极难浸金矿.矿石主要金属矿物为黄铁矿、毒砂.脉石矿物主要为石英、绢云母、白云石、方解石、伊利石黏土矿物等.金的赋存状态绝大多数是"不可见金",主要为次显微、超显微的包裹金以及胶体金.金主要包裹于毒砂和黄铁矿晶体中.矿石中金矿物主要为自然金,少为银金矿.矿石金回收率低的原因主要是包裹金,矿石含砷、碳质以及黏土矿物.     

Reductive leaching of manganese from low-grade pyrolusite ore in sulfuric acid using pyrolysis-pretreated sawdust as a reductant

Manganese (Mn) leaching and recovery from low-grade pyrolusite ore were studied using sulfuric acid (H₂SO₄) as a leachant and pyrolysis-pretreated sawdust as a reductant. The effects of the dosage of pyrolysis-pretreated sawdust to pyrolusite ore, the concentration of sulfuric acid, the liquid/solid ratio, the leaching temperature, and the leaching time on manganese and iron leaching efficiencies were investigated. Analysis of manganese and iron leaching efficiencies revealed that a high manganese leaching efficiency was achieved with low iron extraction. The optimal leaching efficiency was determined to be 20wt% pyrolysis-pretreated sawdust and 3.0 mol/L H₂SO₄ using a liquid/ solid ratio of 6.0 mL/g for 90 min at 90℃. Other low-grade pyrolusite ores were tested, and the results showed that they responded well with manganese leaching efficiencies greater than 98%.     

湖南某难处理金矿的加压预氧化-氰化浸金试验研究

针对湖南某难处理金精矿进行预处理技术研究.该矿含砷(质量分数)为11.28%,金的直接氰化浸出率为21.91%.矿石中的砷以毒砂形式存在.载金矿物为毒砂和黄铁矿等硫化物,金为微细浸染型被毒砂和黄铁矿包裹.通过加压预氧化,对矿石进行氰化浸金试验研究.加压氧化最佳条件为初始酸度1 mol/L,木质素磺酸钠5 g/t,硝酸硫酸比7∶1,氧压0.6 MPa,搅拌速度300 r/min,时间100 min,温度100℃,矿浆浓度20%.试验表明经过加压试验后,金的氰化浸出率达到90.87%,与未预处理相比提高了68.96%,达到了较好的试验效果.     

贵港新民矿区的银铜矿选矿试验研究

采用堆浸工艺对贵港新民矿区的氧化矿和混合矿进行选矿试验研究.贵港新民矿区混合矿和氧化矿中的铜、银采用堆浸回收工艺可以得到充分回收,铜的平均回收率为80.02%,银的平均回收率为74.70%,可回收的铜是664.65t×80.02%=531.85t,银是9.54t×74.70%=7.13t,已经达到铜、银回收的目的.     

广西金牙难浸金矿的工艺矿物学研究

为了给含砷金矿的提金工艺流程提供理论依据,对广西金牙金矿的矿石开展了工艺矿物学研究.该矿是典型的含砷难浸复杂金矿,矿石含Au为6.28 g/t,含Ag为1.37 g/t.As的质量分数为0.58%,S的质量分数为3.10%,C的质量分数为1.76%,其中有机碳的质量分数为0.21%.金精矿含Au为52.61 g/t,含Ag为6.00 g/t.As的质量分数11.32%,S的质量分数为29.32%,C的质量分数为0.35%.矿石中的主要金属矿物为毒砂、黄铁矿,其次有方铅矿、闪锌矿和黄铜矿等.载金矿物主要有毒砂、黄铁矿;金的赋存形态为次显微金;矿石的有害组分为砷、碳质和黏土矿物.含砷矿物是以毒砂、...     

铜(Ⅰ)离子对氰化物溶液中金属离子存在形态的影响

提出了可以描述在各种金属离子浓度和不同的pH条件下,随铜盐添加量的增加,氰化物溶液中金属离子和CN-存在形态的公式.基于其计算结果,探讨了将铜盐加入含金银的氰化物溶液中时金银的沉淀机理,以及在矿石中铜含量较高时氰化物消耗量增加而金银浸出率降低的原因.将铜盐加入氰化物溶液中时,铜(Ⅰ)离子首先与溶液中游离CN-反应,然后从锌、镉、镍等金属的氰根配合物中"劫持"几乎全部的CN-,以CuCN形式生成沉淀,金银的氰根配合物被"劫持"CN-,以AuCN和AgCN型沉淀物沉淀.     

硫酸中香蕉皮还原低品位锰矿的浸出行为及动力学模型

Manganese was leached from a low-grade manganese ore (LGMO) using banana peel as the reductant in a dilute sulfuric acid medium. The effects of banana peel amount, H₂SO₄ concentration, reaction temperature, and time on Mn leaching from the complex LGMO were studied. A leaching efficiency of ~98% was achieved at a leaching time of 2 h, banana peel amount of 4 g, leaching temperature of 120°C, manganese ore amount of 5 g, and sulfuric acid concentration of 15vol%. The phase, microstructural, and chemical analyses of LGMO samples before and after the leaching process confirmed the successful leaching of manganese. Furthermore, the leaching process followed the shrinking core model and the leaching rate was controlled by a surface chemical reaction (1 ? (1 ? x)1/3 = kt) mechanism with an apparent activation energy of 40.19 kJ·mol?1.     

高压脉冲放电预处理强化卡林金浸出效果分析

A high-voltage pulsed discharge (HVPD) pretreatment was used to strengthen the leaching effect of Carlin-type gold ore containing arsenic. Optimal results of the pretreatment experiments were obtained at the following operating conditions: a spherical gap spacing of 20 mm, pulse number of 100, and voltage of 30 kV. The leaching rate of gold was increased by 15.65% via the HVPD pretreatment. The mass fraction of –0.5+0.35 mm and –0.35+0.1 mm was increased by 10.97% and 6.83% compared to the untreated samples, respectively, and the Au grade of –0.1 mm was increased by 22.84%. However, the superiority of the HVPD pretreatment would be weakened by prolonged grinding time. Scanning electron microscopy results indicated that the pretreated products presented as a melting state and then condensation, accompanying by some pore formation. More micro-cracks were generated at the interface of the ore and the original crack were expended via pulsed discharge pretreatment, with the contact area between the leaching reagent and ore increased, the leaching reaction rate enhanced and the leaching effect strengthened.     

微生物燃料电池用于低品位锰矿浸提的研究

为提高低品位锰矿的利用,实现有机废水对锰矿物粉的浸提,通过改造微生物燃料电池(MFC),在阴极反应池中增加电解室及矿物质室,构建用于锰矿湿法浸提的MFC反应器,实现有机废水与锰矿物粉的还原氧化反应的分离。结果显示,以乙酸钠为碳源,以低品位锰矿粉为阴极的MFC输出电压最高可达0.81 V,是以K₃[Fe(CN)₆]为阴极液(0.631 V)的1.23倍。在相同条件下,矿物浸提MFC对COD的去除率可达90.9%,高于对照组(87.5%),而降解时间为3 d,显著少于对照组(5.2 d)。在降解COD能力的提升上,可实现对低品位锰矿粉中MnO₂的还原,其锰含量由原矿粉的23%降至0.98%,浸提率可达95.7%。进一步通过高通量测序对阳极端菌群结构进行分析发现,其主要菌群为地杆菌属(Geobacter),相对于对照组的85%,矿物浸提MFC中该属比例占总菌群的95%。结果表明,矿物浸提MFC可有效地将有机降解与矿物浸提耦合,避免两者直接混合反应带来的二次废水污染及浸提产物硫酸锰的净化问题,在提高MFC产电效率、处理废水的同时...     

Comprehensive recovery of gold and base-metal sulfide minerals from a low-grade refractory ore

The comprehensive recovery of small amounts of valuable minerals such as gold and base-metal sulfide minerals from a low-grade refractory ore was investigated. The following treatment strategy was applied to a sample of this ore: gold flotation–gold concentrate leaching–lead and zinc flotation from the gold concentrate leaching residue. Closed-circuit trials of gold flotation yielded a gold concentrate that assayed at 40.23 g·t-1 Au with a recovery of 86.25%. The gold concentrate leaching rate was 98.76%. Two variants of lead-zinc flotation from the residue—preferential flotation of lead and zinc and bulk flotation of lead and zinc—were tested using the middling processing method. Foam from the reflotation was returned to the lead rougher flotation or lead–zinc bulk flotation, whereas middlings from reflotation were discarded. Sulfur concentrate was a byproduct. The combined strategy of flotation, leaching, and flotation is recommended for the treatment of this kind of ore.     

难处理金矿中伴生矿物对氰化浸出的影响

对金矿石中常见的几种伴生矿物在氰化浸出中的影响进行了分析,同时采用化学试剂配制标准液的方式,考察了Fe2+,Cu2+,As3+对氰化物消耗的影响.试验结果表明:铁矿物中,磁黄铁矿对氰化浸出的影响较大,使溶金速率下降28.1%,氰化物耗量增加4倍,而黄铁矿与赤铁矿对氰化浸出的影响较小;铜矿物中,黄铜矿与辉铜矿对氰化浸出都具有很大影响,其中辉铜矿可使溶金速率下降36.81%,氰化物耗量增加10倍;砷矿物中,雄黄与雌黄对氰化浸出极其有害,使溶金速率分别下降41.95%和49.90%,氰化物耗量分别增加13.8倍和15.0倍,相反毒砂在氰化体系中比较稳定,对氰化浸出的影响较小.离子耗氰试验中,Fe2+...     

碳质金矿石预氧化焙烧堆浸提金的研究

介绍了对辽宁丹东某金矿碳质硅化低硫金矿石的焙烧预氧化处理及焙砂直接堆浸的试验研究·分析了不同温度、不同气氛及不同时间条件下的焙砂的氧化状态及影响金浸出率的NaCN的质量分数、喷淋强度、焙砂粒度及喷淋时间等主要因素·实验结果表明,先在450℃,通入少量空气(含氧5%～10%)的条件下,焙烧1h(脱砷),然后,在650℃,通入充足空气的条件下,焙烧2h,矿石中的硫化物和碳物质的氧化率和灰化率分别达98%和97%;当NaCN的质量分数为0 10%～0 15%,喷淋强度为15 0L/(m2·h),焙砂粒度为0～3mm,喷淋时间为8～10天,金的浸出率为84 8%·同时,推荐了焙砂直接堆浸的原则工艺流程...     

难处理金精矿的加压氧化一氯化浸出实验

采用加压氧化法对国内某难处理金精矿进行预处理,考察了反应温度、精矿粒度、氧分压、初酸浓度、反应时间对金精矿脱硫率和金浸出率的影响.利用XRD,XRF,SEM,EDX技术对金精矿原矿及浸出渣进行分析表征,实验结果表明,在反应温度180℃,精矿粒度-0.075～+0.061 mm,氧分压0.8 MPa,初酸质量浓度60 g...     

New insights into the extraction of invisible gold in a low-grade high-sulfur Carlin-type gold concentrate by bio-pretreatment

To extract gold from a low-grade (13.43 g/t) and high-sulfur (39.94wt% sulfide sulfur) Carlin-type gold concentrate from the Nibao deposit, Guizhou, a bio-pretreatment followed by carbon-in-pulp (CIP) cyanide leaching process was used. Various methods were used to detect the low-grade gold in the concentrate; however, only time-of-flight secondary-ion mass spectrometry (TOF-SIMS) was successful. With bio-pretreatment, the gold recovery rate increased by approximately 70.16% compared with that obtained by direct cyanide leaching of the concentrate. Various attempts were made to increase the final gold recovery rate. However, approximately 20wt% of the gold was non-extractable. To determine the nature of this non-extractable gold, mineralogy liberation analysis (MLA), formation of secondary product during the bio-pretreatment, and the preg-robbing capacity of the carbonaceous matter in the ore were investigated. The results indicated that at least four factors affected the gold recovery rate:gold occurrence, tight junctions of gold-bearing pyrite with gangue minerals, jarosite coating of the ore, and the carbonaceous matter content.     

甘肃早子沟金矿石工艺矿物学研究

甘肃早子沟金矿为典型卡林型金矿,该矿含金4.09 g/t,锑0.46%,砷0.39%,主要金属矿物有黄铁矿、毒砂、辉锑矿和褐铁矿,非金属矿物主要有石英、碳酸盐矿物和绢云母,矿石中矿物组成较复杂,但是除金及辉锑矿以外其他元素均无回收价值.矿石中的金矿物主要为自然金,相对质量分数为99.12%,除分布在脉石中的金,辉锑矿是金的重要载体.自然金粒度不均匀,经统计的颗粒全部小于0.075 mm,未发现粗粒金.工艺矿物学研究表明,该矿石难于选冶的主要原因为易泥化矿物、包裹金及含砷锑等耗氰矿物较多.