首页 | 本学科首页   官方微博 | 高级检索  
     检索      

单活塞式液压自由活塞柴油机冷启动过程研究
引用本文:郭锋,黄英,赵长禄,张付军,葛淑娟.单活塞式液压自由活塞柴油机冷启动过程研究[J].北京理工大学学报,2012,32(11):1116-1120.
作者姓名:郭锋  黄英  赵长禄  张付军  葛淑娟
作者单位:北京理工大学机械与车辆学院,北京,100081;北京理工大学机械与车辆学院,北京,100081;北京理工大学机械与车辆学院,北京,100081;北京理工大学机械与车辆学院,北京,100081;北京理工大学机械与车辆学院,北京,100081
基金项目:国家部委基础科研项目(A2220060053)
摘    要:基于所研制的单活塞式液压自由活塞柴油机原理样机,对冷启动过程中的循环波动进行了试验研究.研究结果表明,约150循环后发动机完成冷启动过程,进入稳定工作状态.冷启动过程中,随着工作循环数的不断增加,下止点位置、反弹量和停留位置的波动逐渐减小;气缸内最大燃烧压力值逐渐减小;压升率极值波动较大并大于临界值.稳定运转后,最大压升率波动减小并趋于稳定;燃烧放热率峰值随工作循环数的增加有所降低,速燃期持续时间没有明显变化;缓燃期和后燃期持续时间逐渐增加;燃烧过程逐渐趋于稳定.

关 键 词:动力机械工程  自由活塞发动机  柴油机  冷启动
收稿时间:2011/6/22 0:00:00

Investigation of Cold Starting Process of Single Piston Hydraulic Free-Piston Diesel Engine
GUO Feng,HUANG Ying,ZHAO Chang-lu,ZHANG Fu-jun and GE Shu-juan.Investigation of Cold Starting Process of Single Piston Hydraulic Free-Piston Diesel Engine[J].Journal of Beijing Institute of Technology(Natural Science Edition),2012,32(11):1116-1120.
Authors:GUO Feng  HUANG Ying  ZHAO Chang-lu  ZHANG Fu-jun and GE Shu-juan
Institution:School of Mechanical Engineering, Beijing Institute of Technology, Beijing 100081, China;School of Mechanical Engineering, Beijing Institute of Technology, Beijing 100081, China;School of Mechanical Engineering, Beijing Institute of Technology, Beijing 100081, China;School of Mechanical Engineering, Beijing Institute of Technology, Beijing 100081, China;School of Mechanical Engineering, Beijing Institute of Technology, Beijing 100081, China
Abstract:On the basis of principle prototype of a single piston hydraulic free-piston diesel engine (HFPDE), the cycle-to-cycle variations in cold starting process were investigated. The results indicate that the cold starting process was completed after 150 engine cycles. During the cold starting process, a few of dependent relationship could be observed as follows. The variation of bottom dead center reduces as engine cycles increase, so does piston bouncing and dwelling position. The maximum pressure in cylinder is reduced gradually. The peak pressure rise rate is larger than critical value and fluctuates greatly until stable operation. The peak heat release rate also decreases with the increase of engine cycles. As engine cycles increase, the time duration at pre-mixed combustion phase is almost constant, while it becomes longer at mixing-controlled combustion phase and late combustion phase. The combustion process gradually stabilizes after cold starting process.
Keywords:power machinery engineering  free-piston engine  diesel engine  cold starting
本文献已被 CNKI 万方数据 等数据库收录!
点击此处可从《北京理工大学学报》浏览原始摘要信息
点击此处可从《北京理工大学学报》下载免费的PDF全文
设为首页 | 免责声明 | 关于勤云 | 加入收藏

Copyright©北京勤云科技发展有限公司  京ICP备09084417号