| 玉米秸秆稀酸-蒸汽爆破预处理和水解糖化的试验研究 |
| |
| 引用本文： | 韩沐昕,谭羽非,刘欢鹏,李冬梅.玉米秸秆稀酸-蒸汽爆破预处理和水解糖化的试验研究[J].科学技术与工程,2014,14(10):290-294. |
| |
| 作者姓名： | 韩沐昕 谭羽非 刘欢鹏 李冬梅 |
| |
| 作者单位： | 1. 哈尔滨工业大学, 2. 黑龙江建筑职业技术学院,哈尔滨工业大学 市政环境工程学院,哈尔滨工业大学能源科学与工程学院,哈尔滨工业大学 城市水资源和水环境国家重点实验室,市政环境工程学院 |
| |
| 基金项目： | 国家自然科学基金项目（面上项目，重点项目，重大项目） |
| |
| 摘 要： | 考察了玉米秸秆经1%(w/w)稀硫酸和水分别浸泡后在不同汽爆压力(分别确定研究压力为1.5 MPa,1.8 MPa和2.0 MPa)和保压时间(分别为4 min,6 min和8 min)下进行蒸汽爆破预处理的处理效果。分析了预处理后固体和液体部分的主要成分和含量。通过考察预处理后固体部分经过纤维素酶作用后所得到的葡萄糖得率,确定了最佳的稀酸-蒸汽爆破预处理工艺。在1%稀硫酸预浸12 h后,采用1.8 MPa汽爆条件保压8 min,经过预处理玉米秸秆的最大葡萄糖得率为26.9 g/100g原料;在该条件下,预处理后过滤液中总糖得率最高为34.5 g/100 g原料。
|
| 关 键 词： | 预处理 玉米秸秆 稀酸 稀酸-蒸汽爆破 酶水解 |
| 收稿时间： | 2013/10/17 0:00:00 |
| 修稿时间： | 2013/11/8 0:00:00 |
Enzymatic hydrolysis of corn stalk by dilute acid- steam explosion |
| |
| HAN Munxin,and Li Dongmei.Enzymatic hydrolysis of corn stalk by dilute acid- steam explosion[J].Science Technology and Engineering,2014,14(10):290-294. |
| |
| Authors: | HAN Munxin and Li Dongmei |
| |
| Abstract: | In order to increase the enzymic hydrolysis of corn stalk, steam explosion of corn stalk was carried out under various pretreatment conditions (1.5Mpa, 1.8MPa and 2.0Mpa, 4min, 6min and 8min) after impregnation of the corn stalk with 1.0% (w/w) H2SO4 or water. Composition of solid and filtrate obtained after pretreatment, enzymatic digestibility of pretreated corn stalk at different experimental conditions was analyzed. The best pretreatment conditions to obtain high conversion yield to glucose after steam-explosion were 1.8 Mpa and 8 min, in acid-impregnated corn stalk. for 24 h. The highest glucose yield referred to raw material is 26.9g /100g corn stalk and sugars recovery yield in the filtrate is 34.5g/100g corn stalk). |
| |
| Keywords: | pretreatment corn stalk dilute acid dilute acid- steam explosion enzymatic saccharification |
| 本文献已被 CNKI 等数据库收录！ |
| 点击此处可从《科学技术与工程》浏览原始摘要信息 |
| 点击此处可从《科学技术与工程》下载免费的PDF全文 |
|
